Uncategorized

Keep your eBike healthy

PRA_0811

The electric assisted bike offers many new possibilities, especially for those who find the hills getting bigger as the years roll on. It also opens opportunities for exploring places you would not go with a regular bike. Ebike owners need to be aware that the new technology exerts greater force on mechanical parts than regular bikes, so basic maintenance can really extend an ebike’s life. The following non-technical tips will help to care for yours.

Q Station

Cleanliness, lubrication, and tightening

Dirt particles can increase wear and tear on chains and gears, so it is important that you keep the bike clean and regularly check nuts, bolts, and screws to ensure correct tightening. The brake rotor can quickly build up grime and adversely affect brake performance, so a simple dab of pure alcohol on a microfibre cloth will keep the rotor shiny and clean. An old toothbrush will work wonders on the chain, as will a few drops of dry lubrication.

Your ebike’s electrical components are mostly sealed units and require no user maintenance. However, the parts that need regular inspections are the brakes, chain and gears.

St Pats

Brakes

The addition of a motor and battery make ebikes heavier, so they require more braking power. This results in more wear and tear on brake pads and rotor. How do you know when to replace brake parts?

There are two signs that attention is needed: one is audible the other tactile. If your brakes begin to squeak or if your brake lever travel is excessive, it’s time to ask your bike retailer to check the pads. The pad chamber is a small dark place better suited to younger eyes, but it only takes a few seconds to diagnose if:

1 your brake lever needs adjusting

2 your brake pads need replacing

3 your brake rotor needs replacing

4 your hydraulic fluid needs replenishing

How long do brake components usually last? It depends entirely on how and where you ride. If you ride on flat paths and do not need constant or strong braking, your brakes may last 2,000kms. On the other hand, if you ride on variable terrain and use brakes often, they should be inspected each 1,000kms. The rotor typically lasts 2-3 brake pad changes.

As a ball-park indicator, my last brake service had new front and rear pads (about $70) and a new rotor (about $80), plus an hour’s labour charge.

3

Gears

Electric assistance generates more torque on the bike chain and the gear rings, so these parts will wear out sooner than on regular bikes.

There are two signals to watch for that might indicate a service is needed:

1 If your chain jumps between gears or it is difficult to select a gear, then an adjustment may be needed.

2 If your chain slips over the same gear ring while riding, then the chain or gear cassette may be worn and need replacing. A loose fit between chain and gear ring can also suggest worn parts.

Generally, the gear cassette and chain wear at the same rate, so they need to be changed at the same time. I had both of mine changed recently for around $200.

15

 Summary

Apart from regularly checking your tyre pressures, it is not difficult to maintain a healthy ebike. Most require a short service/system check after the first 500kms and again after the first year.

If you experience a malfunction, contact your ebike retailer. Alternatively, you can contact ebike specialists like Sydney Electric Bikes with stores in Pyrmont, Engadine, and Hornsby. If you are on Sydney’s Northern Beaches, the Bike Factory Brookvale is a centrally located and friendly drop-in bike hub.

Happy riding

healthy ebike

7 replies »

  1. A thought on Batteries from personal experience. I own a Cannondale Neon Mountain bike. After washing the bike with garden hose the battery will not charge. Long story short the battery is back at dealers while they decide on warranty. Be very careful , I would have thought a mountain bike would be able to withstand a splash !

    Like

    • Thanks for the warning, although I’m suspecting a warranty issue. If its not, then its a serious problem for ebike technology. Bikes of that calibre are expected to handle lots of wet, so good luck.

      Like

  2. An idea for charging ebike battery. If you are concerned about your battery failing while out on a ride consider this. Buy an inverter ( avail from Jaycar ) take the battery off your bike, hook the inverter into your cars cigarette lighter, and plug your battery into the inverter. INSTANT CHARGING while you are driving or on a break from riding. Or worse, if your battery goes flat during a ride. If vehicle stationery make sure the car is turned on and idling. Alternatively you could leave the battery on your bike rack, hook it up via a long extension chord into the inverter which is plugged into the cigarette lighter and charge while driving to or from your ride. This long lead should be well taped along the outside doors in through the passenger or back seat side window into the cigarette lighter. You don’t want the extension lead flopping all over the place whilst you are driving. Flat battery syndrome whilst on ride solved.

    Liked by 1 person

  3. Hi Just got a Milano Plus ebike and yet to take it on a long ride.I am concerned about the prospect of a puncture.What advice can you recommend?Thanks David Mark

    Like

    • Hi David. This is an issue that causes anxiety for all riders. If you are ‘handy’ with tyre levers and dont mind carrying a spare, the simplest solution is DIY. However, many seniors would find this difficult. On my long distance touring ebike, I went tubeless a year ago and have not had a flat since. The benefits of tubeless are many: pinch flats are eliminated because there is no inner tube; you can ride at lower pressures and thus get a softer ride; and if you do pick up a nasty thorn, you can repair most of them from the outside with a plug repair kit. In case of a small puncture, the tyre is able to self-seal by forcing out sealant which dries in the hole (turn the wheel so hole is at low point where sealant pools). Also make sure you carry a good pump as many punctures are slow leaks and re-pumping every few kms can sometimes save the day. Hope this helps to get you onto that first long ride.

      Like

Leave a Reply to eBiker Diary Cancel reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out /  Change )

Google photo

You are commenting using your Google account. Log Out /  Change )

Twitter picture

You are commenting using your Twitter account. Log Out /  Change )

Facebook photo

You are commenting using your Facebook account. Log Out /  Change )

Connecting to %s